MATERIAL SAFETY DATA SHEET

AIROSOL COMPANY, INC.

MCKAY CHEMICALS MECHANICS BRAND

1101 Illinois, PO Box 120, Neodesha KS 66757 - Phone 620-325-2666

MATERIAL SAFETY DATA SHEET

PRODUCT NAME:	Trans Tune	Hmis Codes:	H	F	R	P
PRODUCT CODE:	50106		1	1	0	0

SECTION I - MANUFACTURER IDENTIFICATION

MANUFACTURER’S NAME:	Airosol Company, Inc.
ADDRESS:	PO Box 120, Neodesha KS 66757
EMERGENCY PHONE:	1-800-535-5053
INFORMATION PHONE:	1-800-633-9576
DATE REVISED:	01/05/2002

SECTION I I- HAZARDOUS INGREDIENTS/SARA III INFORMATION

OCCUPATIONAL EXPOSURE LIMITS

HAZARDOUS COMPONENTS	CAS NUMBER	TWA/PEL	ACGIH	%
Severely Hydrotreated Heavy Naphthenic Petroleum Oil	64742-52-5	5 mg/m3	5 mg/m3	45-50
Petroleum distillate	Proprietary	5 mg/m3	10 mg/m3	N/A
Ethyl acrylate	140-88-5	5 ppm	25 ppm	< 0.1
Naphthalene	91-20-3	10 ppm	10 ppm	0.7
Hydrogen Chloride	7647-01-0	5 ppm	5 ppm	< 0.1
Phenol	108-95-2	5 ppm	5 ppm	< 0.1
Phosphoric Acid	7664-38-2	N/A	1 mg/m3	< 0.1

The composition of this mixture may be proprietary information. In the event of a medical emergency, compositional information will be provided to a physician or nurse.

SECTION III- PHYSICAL/CHEMICAL CHARACTERISTICS

BOILING POINT:	> 520 °F	SPECIFIC GRAVITY:	0.905 @ 77°F
VAPOR DENSITY:	<1 (Air = 1)	EVAPORATION RATE:	1000 x slower than ethyl ether
APPEARANCE AND ODOR:	Brown/Red, mineral oil odor	SOLUBILITY IN WATER:	Insoluble

SECTION IV- FIRE AND EXPLOSION HAZARD DATA

FLASH POINT:

<250°F

METHOD USED:

COC

FLAMMABLE LIMITS IN AIR BY VOLUME:

LOWER:

UPPER:

EXTINGUISHING MEDIA: Dry chemical, foam or water spray.
SPECIAL FIREFIGHTING PROCEDURES:	Wear self-contained breathing apparatus and full protective clothing.
UNUSUAL FIRE AND EXPLOSION HAZARDS: Toxic fumes, dense smoke, oxides of sulfur, oxides of nitrogen, and carbon monoxide.
SPECIAL FIREFIGHTING PROCEDURES: Wear self contained breathing apparatus and full protective clothing.
UNUSUAL FIRE AND EXPLOSION HAZARDS:		None known.

Page 1 of 4

PRODUCT NAME:	Trans Tune
PRODUCT CODE:	50106

SECTION V- REACTIVITY DATA

STABILITY: Stable

CONDITIONS TO AVOID: Sources of ignition. Do not heat over 155°F to avoid possible release of hydrogen sulfide.

INCOMPATIBILITY (MATERIALS TO AVOID): Strong oxidizing agents.

HAZARDOUS DECOMPOSITION OR BYPRODUCTS: Hydrogen sulfide, oxides of carbon, nitrogen, and sulfur.

HAZARDOUS POLYMERIZATION: Will not occur.

SECTION VI- HEALTH HAZARD DATA

INHALATION HEALTH RISKS AND SYMPTOMS OF EXPOSURE: Negligible hazard at ambient temperature (0 to 100°F, -18 to 38°C). Avoid breathing vapors or mists.

NATURE OF HAZARD:

EYES:	Slightly irritating but does not injure eye tissue.
INGESTION:	Harmful if aspirated into lungs.

CARCINOGENICITY:	NTP?	IARC?	OSHA REGULATED?
Presently not on any list.

MEDICAL CONDITIONS GENERALLY AGGRAVATED BY EXPOSURE: N/A

EMERGENCY AND FIRST AID PROCEDURES:

INGESTION: DO NOT induce vomiting. Give 2 (two) glasses of water. Call a physician immediately.

INHALATION: Using proper respiratory protection, immediately remove the affected victim from exposure. Administer artificial respiration if breathing is stopped. Keep at rest. Call for prompt medical attention.

SKIN AND EYE CONTACT:

EYES: Immediately flush eyes with large amounts of water for at least 15 minutes. If irritation persists, get medical attention immediately.

SKIN: Flush with large amounts of water; use soap if available. Remove grossly contaminated clothing, including shoes, and launder before reuse.

SECTION VII- PRECAUTIONS FOR SAFE HANDLING AND USE

STEPS TO BE TAKEN IN CASE MATERIAL IS RELEASED OR SPILLED: Eliminate sources of ignition. Prevent additional discharge of material, if possible to do so without hazard. For small spill, implement cleanup procedures and, if in public area, keep public away and advise authorities. Prevent liquid from entering sewers, watercourses, or low areas. Contain spilled liquid with sand or earth.

WASTE DISPOSAL METHOD: Dispose in accordance with federal, state, and local regulations regarding pollution.

PRECAUTIONS TO BE TAKEN IN HANDLING AND STORING: Keep away from heat, sparks, or open flame.

OTHER PRECAUTIONS: NA.

SECTION VIII- CONTROL MEASURES

RESPIRATORY PROTECTION: Usually not required if it is used as it is described on the label.

Page 2 of 4

PRODUCT NAME:	Trans Tune
PRODUCT CODE:	50106

SECTION VIII- CONTROL MEASURES (continued)

VENTILATION: Provide adequate ventilation to keep mist or vapors below allowable exposure levels.

PROTECTIVE GLOVES: For prolonged or repeated contact, wear gloves made of polyvinyl chloride, neoprene, nitrile, polyvinyl alcohol, and viton.

EYE PROTECTION: Recommend safety glasses with unperforated sideshields.

OTHER PROTECTIVE CLOTHING OR EQUIPMENT: Long sleeves and long pants.

WORK/HYGIENIC PRACTICES: Wash hands after use.

SECTION IX - REGULATORY INFORMATION

SUPERFUND AMENDMENTS AND REAUTHORIZATION ACT OF 1986 (SARA) TITLE III:
Chemical CAS NUMBER CONCENTRATION %

Ethyl acrylate	140-88-5	< 0.1
Naphthalene	91-20-3	0.7
Phenol	108-95-2	< 0.1

FEDERAL EPA: Comprehensive Environmental Response,Compensation,and Liability Act of 1980 (CERCLA) requires the notification of the National Response Center of release of quantities of hazardous substances equal to or greater than the reportable quantities (rqs) in 40 CFR 302.4.
CHEMICAL CAS NUMBER CONCENTRATION % RQs IN #'S

UPPER BOUND

Ethyl acrylate	140-88-5	< 0.1	1000
Naphthalene	91-20-3	0.7	100
Hydrogen Chloride	7647-01-0	< 0.1	5000
Phenol	108-95-2	< 0.1	1000
Phosphoric Acid	7664-38-2	< 0.1	5000

CALIFORNIA PROPOSITION 65: Yes

CHEMICAL CAS NUMBER CONCENTRATION %

Ethyl acrylate

140-88-5

< 0.1

MASSACHUSETTS RIGHT TO KNOW: YES

Ethyl acrylate	140-88-5	< 0.1
Naphthalene	91-20-3	0.7
Hydrogen Chloride	7647-01-0	< 0.1
Phenol	108-95-2	< 0.1
Phosphoric Acid	7664-38-2	< 0.1

PENNSYLVANIA RIGHT TO KNOW: YES

Ethyl acrylate	140-88-5	< 0.1
Naphthalene	91-20-3	0.7
Hydrogen Chloride	7647-01-0	< 0.1
Phenol	108-95-2	< 0.1
Phosphoric Acid	7664-38-2	< 0.1

Page 3 of 4

PRODUCT NAME:	Trans Tune
PRODUCT CODE:	50106

SECTION IX - REGULATORY INFORMATION (continued)

CHEMICAL CAS NUMBER CONCENTRATION %

NEW JERSEY RIGHT TO KNOW: YES

Ethyl acrylate	140-88-5	< 0.1
Naphthalene	91-20-3	0.7
Hydrogen Chloride	7647-01-0	< 0.1
Phenol	108-95-2	< 0.1
Phosphoric Acid	7664-38-2	< 0.1

TOXIC SUBSTANCES CONTROL ACT (TSCA) STATUS: Listed

CARCINOGENITY CHEMICAL IARC NTP OSHA
NONE LISTED

SECTION X- DISCLAIMER

DISCLAIMER: The information in this document is believed to be correct as of the date issued. However, no warranty of MERCHANTABILITY, fitness for any particular purpose, or any other warranty is expressed or to be implied regarding the accuracy or completeness of this information or the product, the safety of this product, or the hazards related to its use. This information and product are furnished "as is" and on the condition that the person receiving them shall make their own determination as to the suitability of the product for their particular purpose and on the condition that they assume the risk of their use thereof.

Page 4 of 4