AIROSOL COMPANY, INC.

MCKAY CHEMICALS                   MECHANICS BRAND

11th & Illinois, PO Box 120, Neodesha KS 66757 - Phone 316/325-2666

 

MATERIAL SAFETY DATA SHEET

 

PRODUCT NAME:

BRAKE LUBE GREASE (WHITE LITHIUM)

Hmis Codes:

H

F

R

P

PRODUCT CODE:

50405

 

0

1

0

B

 

SECTION I - MANUFACTURER IDENTIFICATION

 

MANUFACTURER’S NAME:

Airosol Company, Inc.

ADDRESS:

PO Box 120, Neodesha KS 66757

EMERGENCY PHONE:

1-800-535-5053

INFORMATION PHONE:

1-800-633-9576

DATE REVISED:

06-04-2001

 

SECTION I I- HAZARDOUS INGREDIENTS/SARA III INFORMATION

 

NONE

 

This product contains the following chemical(s) subject to the reporting of Section 313 of Title III of the Superfund Amendments and Reauthorization Act of 1986 and 40 CFR Part 372: (Specific chemical Zinc compound with maximum % Zine is 0.2%.

 

SECTION III- PHYSICAL/CHEMICAL CHARACTERISTICS

 

BOILING POINT:

No data available

SPECIFIC GRAVITY:

0.943 (H20=1)

VAPOR DENSITY:

NA

EVAPORATION RATE:

NA

APPEARANCE AND ODOR:

Off White Grease/mineral oil

SOLUBILITY IN WATER:

Negligible at 25° C

TOXIC & HAZARDOUS INGREDIENTS:

None

VISCOSITY SUS AT

100°F:

Greater than or = to 100

VAPOR PRESSURE:

N/A

 

 

 

SECTION IV- FIRE AND EXPLOSION HAZARD DATA

 

FLASH POINT:

374°F

METHOD USED:

COC

 

FLAMMABLE LIMITS IN AIR BY VOLUME:  No data available.

 

 

 

 

EXTINGUISHING MEDIA:  Use water fog, dry chemical, carbon dioxide or earth/sand.

 

SPECIAL FIREFIGHTING PROCEDURES:  Dense smoke.  Fightfighters should wear approved self-contained breathing apparatus.  Do not use water except as fog.

 

UNUSUAL FIRE AND EXPLOSION HAZARDS:  Dense smoke.

 

 

SECTION V- REACTIVITY DATA

          

STABILITY:  Stable

INCOMPATIBILITY (MATERIALS TO AVOID):  Strong oxidizers such as hydrogen peroxide, bromine and chronic acid.

 

 

Page 1

PRODUCT NAME:

BRAKE LUBE GREASE (WHITE LITHIUM)

PRODUCT CODE:

50405

 

SECTION V- REACTIVITY DATA (continued)

 

HAZARDOUS DECOMPOSITION OR BYPRODUCTS: Carbon monoxide and carbon dioxide from burning.  Zinc oxide, oxides of sulfur, sulfur dioxide or hydrogen sulfide, depending upon decomposition conditions, oxides of barium.

 

HAZARDOUS POLYMERIZATION: Will not occur.

 

SECTION VI- HEALTH HAZARD DATA

 

CHRONIC EFFECTS OF OVEREXPOSURE:  None when used with good personal hygiene practices.  May otherwise cause skin and eye irritation upon prolonged or repeated contact.

ACUTE TOXICOLOGICAL PROPERTIES:  No data available.

 

CARCINOGENICITY:

NTP?

IARC?

OSHA REGULATED?

Presently not on any list.

 

 

 

 

EMERGENCY AND FIRST AID PROCEDURES:

DIGESTION:  If swallowed, get medical attention immediately.

 

SKIN AND EYE CONTACT:

EYES:  Immediately flush eyes with large amounts of water for at least 15 minutes.  Hold eyelids apart to ensure complete flushing.  Do not attempt to neutralize with chemical agents.  Get medical help immediately.

SKIN:  Remove excess with cloth or paper and wash area thoroughly with soap and water.  For high pressure injection under the skin see a physician immediately.

INHALATION:  Remove exposed person to fresh air if discomfort is experienced while handling hot product.

 

SECTION VII- PRECAUTIONS FOR SAFE HANDLING AND USE

 

STEPS TO BE TAKEN IN CASE LARGE AMOUNT OF MATERIAL IS RELEASED OR SPILLED:  Use absorbent sweeping compound to soak up material.  Put into container.  Dispose of as hazardous waste. 

 

WASTE DISPOSAL METHOD:  Dispose of in accordance with EPA, RCRA.

 

PRECAUTIONS TO BE TAKEN IN HANDLING AND STORING:  Keep away from heat, sparks, or open flame.

 

SECTION VIII- CONTROL MEASURES

 

RESPIRATORY PROTECTION:  NA.

VENTILATION:  NA.

PROTECTIVE GLOVES:   NA.

EYE PROTECTION:  Chemical safety goggles and, if handled hot, full face shield.

OTHER PROTECTIVE CLOTHING OR EQUIPMENT:  Long sleeves and long pants.

 

SECTION IX- REGULATORY INFORMATION

 

SUPERFUND AMENDMENTS AND REAUTHORIZATION ACT OF 1986 (SARA) TITLE III:

                                    CHEMICAL                         CAS NUMBER                     CONCENTRATION %

                                    Keep away from children

FEDERAL EPA:  Comprehensive Environmental Response, Compensation and Liability Act of 1980 (CERCLA) requires the notification of the National Response Center of release of quantities of hazardous substances equal to or greater than the reportable quantities (rqs) in 40 CFR 302.4.

                                    Page 2

 

 

PRODUCT NAME:

BRAKE LUBE GREASE (WHITE LITHIUM)

PRODUCT CODE:

50405

 

SECTION IX- REGULATORY INFORMATION (continud)

 

CHEMICAL                         CAS NUMBER                     CONCENTRATION %     RQS IN #’s

                                    None listed

CALIFORNIA PROPOSITION 65:   No

MASSACHUSETTS RIGHT TO KNOW: unknown 

PENNSYLVANIA RIGHT TO KNOW:  Yes

                                    formula trade secret

NEW JERSEY RIGHT TO KNOW:   Yes

                                    zinc oxide                                 1314-13-2                      Not available

TOXIC SUBSTANCES CONTROL ACT (TSCA) STATUS:  Listed

CALIFORNIA VOCS:  NA

NFPA RATING AS AN AEROSOL:  NA

 

SECTION X- DISCLAIMER

 

NOTE:  THE INFORMATION IN THIS DOCUMENT IS BELIEVED TO BE CORRECT AS OF THE DATE ISSUED.  HOWEVER, NO WARRANTY OF MERCHANTABILITY, FITNESS FOR ANY PARTICULAR PURPOSE, OR ANY OTHER WARRANTY IS EXPRESSED OR TO BE IMPLIED REGARDING THE ACCURACY OR COMPLETENESS OF THIS INFORMATION OR THE PRODUCT, THE SAFETY OF THIS PRODUCT, OR THE HAZARDS RELATED TO ITS USE.  THIS INFORMATION AND PRODUCT ARE FURNISHED "AS IS" AND ON THE CONDITION THAT THE PERSON RECEIVING THEM SHALL MAKE THEIR OWN DETERMINATION AS TO THE SUITABILITY OF THE PRODUCT FOR THEIR PARTICULAR PURPOSE AND ON THE CONDITION THEY ASSUME THE RISK OF THEIR USE THEREOF.   

 

 

 

 

Page 3