AIROSOL COMPANY, INC.
MCKAY CHEMICALS
MECHANICS BRAND
11th &
MATERIAL SAFETY DATA SHEET
|
PRODUCT NAME: |
BELT GRIP |
Hmis
Codes: |
H |
F |
R |
P |
|
PRODUCT CODE: |
50603 |
|
2 |
4 |
0 |
G |
|
SECTION I - MANUFACTURER
IDENTIFICATION |
|
MANUFACTURER’S NAME: |
Airosol Company, Inc. |
|
ADDRESS: |
|
|
EMERGENCY PHONE: |
1-800-535-5053 |
|
INFORMATION PHONE: |
1-800-633-9576 |
|
DATE REVISED: |
|
|
SECTION I I-
HAZARDOUS INGREDIENTS/SARA III INFORMATION |
OCCUPATIONAL
EXPOSURE LIMITS
|
HAZARDOUS COMPONENTS |
OSHA |
ACGIH |
OTHER |
% |
CAS
NO. |
|
Petroleum Distillate |
50ppm |
50ppm |
NA |
30-40 |
110-54-3 |
|
Dimethoxymethane |
1000ppm |
1000ppm |
1000ppm(+) |
10-15 |
109-87-5 |
|
Isobutane |
NE |
NE |
NA |
NA |
75-28-5 |
|
Propane |
1000ppm |
NE |
NA |
NA |
74-98-6 |
NOTE: + United
Kingdom Exposure Limit
*All chemical
compounds marked wtih an asterick
(*) are toxic chemicals subject to the reporting requirements of Section 313 of
Title III of the Superfund Amendments and
Reauthorization Act (SARA) of 1985 and 40 CFR Part 372. You must notify each person to whom this
mixture or trade name product is sold.
This statement remains a part of this Material Safety Data Sheet.
|
SECTION III- PHYSICAL/CHEMICAL
CHARACTERISTICS |
|
BOILING POINT: |
ND |
SPECIFIC GRAVITY: |
(H20=1) 0.5999-0.6239 |
|
VAPOR DENSITY: |
(air=1) greater than |
VAPOR PRESSURE: |
(mmHg or psig @ 70F) 45-50 psig |
|
APPEARANCE AND ODOR: |
Light amber with light ethereal odor |
SOLUBILITY IN WATER: VOC CONTENT % BY WT: |
Insoluble 75 |
|
SECTION IV- FIRE AND EXPLOSION
HAZARD DATA |
|
FLASH POINT: |
<20°F |
METHOD USED: |
PMCC |
|
|||
|
FLAMMABLE LIMITS IN AIR BY VOLUME: |
LOWER: |
17.6% |
UPPER: |
1.2% |
|
||
|
EXTINGUISHING MEDIA: Dry chemical, alcohol foam, or CO2. |
|||||||
|
SPECIAL FIREFIGHTING PROCEDURES: Wear self-contained breathing apparatus
when fighting fires containing or around this product. Shut off all sources of ignition, if
possible. Keep exposed containers cool with water spray to prevent
rupture. Evacuate all non-trained personnel. Wear full protective clothing, including
helmet. Ventilate area. Contain spill and dike, if possible. For leaks or spills that have not ignited,
water spray can be used to disperse the flammable vapor and protect personnel
attempting to stop leak. Do not use
direct stream of water because product will float and can be reignited on surface of water. |
|
||||||
|
UNUSUAL FIRE AND EXPLOSION
HAZARDS: Firefighters should wear SCBAs in positive pressure mode with full face
shield. Vapors are heavier than air
and may travel long distances and accumulate in low areas or spread along
ground away from handling site.
Eliminate all sources of ignition as vapor may ignite. Carbon oxides may be formed. |
|||||||
Page
1
PRODUCT
NAME: |
BELT
GRIP |
|
PRODUCT
CODE: |
50603 |
|
SECTION V- REACTIVITY DATA |
|
STABILITY: Stable. Avoid open flames, welding arcs or other
high temperature sources which induce thermal decomposition. Avoid direct sunlight. |
|
INCOMPATIBILITY: Avoid contact with oxygen, hydrogen
peroxide, nitric acid, strong oxidizers, sulfuric acid, hydrochloric acid and
other strong inorganic acids. |
|
HAZARDOUS DECOMPOSITION OR
BYPRODUCTS: Carbon monoxide, methanol,
and formaldehyde. |
|
HAZARDOUS POLYMERIZATION: Will not
occur. |
|
SECTION VI- HEALTH HAZARD DATA |
EFFECTS
OF OVEREXPOSURE:
|
EYES: |
Considered irritating to the eye |
|
|
SKIN CONTACT: Prolonged exposure may cause defatting of the skin which could lead to dryness and
cracking. People prone to skin
sensitiveness may be more sensitive to this product. |
|
|
|
SKIN ABSORPTION: Unlikely that this product would absorb
into skin and cause damage. |
|
|
|
INGESTION: |
Slightly toxic by ingestion. |
|
|
INHALATION: May be irritating to respiratory tract and
a narcotic at very high concentrations. Inhalation at high concentrations
could cause vertigo, drowsiness, fatigue, loss of appetite, paralysis in
distal extremities, muscle weakness, cold pulsation in extremities, blurred
vision, headache, anorexia and onset of polyneuropathy. Can cause injury to lungs, liver, kidney
and head. |
|
|
|
SYSTEMIC AND OTHER EFFECTS: |
Hallucinations, structural change in
nerve or sheath. |
|
EMERGENCY
AND FIRST AID PROCEDURES: |
|
EYES:
In case of contact, immediately flush eyes with large amounts of water
for 15 minutes. Make sure to remove
contact lenses and lift eyelids to ensure complete flushing. If irritation occurs, contact physician
immediately. |
|
SKIN:
Immediately wash contaminated area thoroughly with soap and
water. Remove and launder contaminated
clothing before use. Destroy or properly
dispose of contaminated shoes. If
irritation is severe, contact physician immediately. |
|
INHALATION: Move person to area with fresh air. If breathing has stopped, give CPR. If breathing is difficult, give oxygen. Contact physician immediately. |
|
INGESTION: Unlikely as an aerosol but, if ingested, DO
NOT INDUCE VOMITING.
Give one to two glasses of H20. Never give anything by mouth to an
unconscious person. Call physician
immediately. |
|
SECTION VII- PRECAUTIONS FOR
SAFE HANDLING AND USE |
ENVIRONMENTAL
AND DISPOSAL INFORMATION
|
STEPS TO BE TAKEN IN CASE LARGE
AMOUNT OF MATERIAL IS RELEASED OR SPILLED:
Ventilate area, especially low places where heavy vapors might
collect. Extinguish all ignition
sources. Contain spill. Cover with
inorganic absorbant material. Collect spilled material. Clean up residue. Place in approved DOT container for disposal.Refer to other sections of this MSDS for
information regarding physical and health hazards, respiratory protection,
ventilation and personnel protective equipment. |
|
WASTE DISPOSAL METHOD: Reclaim by distillation if possible or
remove to permitted waste disposal facility in
accordance with federal, state, and local regulations. |
|
REGULATORY INFORMATION: Since regulations vary, consult applicable
regulations or authorities before disposal.
In the event of uncontrolled release of this material from the
container, the user should determine if release is reportable. U. S. EPA hazardous waste number for liquid
concentrate is D001. |
|
ENVIRONMENTAL DATA: No data available. |
Page
2
|
PRODUCT
NAME: |
BELT
GRIP |
|
PRODUCT
CODE: |
50603 |
|
SECTION VIII- HANDLING AND
STORAGE PRECAUTIONS |
|
HANDLING AND STORAGE
PRECAUTIONS: Store in tightly sealed
containers. Keep away from heat,
sparks and open flame. Do not get in
eyes, on skin or clothing. Do not
breathe vapor or mist. Do not store or
transfer to unmarked container. Do not
store in direct sunlight. Store
containers below 120° F. Read label
before using. Do not smoke when
handling or using this product. Do not
cut on empty containers as they may contain vapors that are flammable. |
|
SECTION IX - SPECIAL PROTECTION
INFORMATION |
|
RESPIRATORY PROTECTION (SPECIFY
TYPE): Select one of the following
NIOSH approved respirators based on airborne concentration of contaminants
and in accordance with OSHA regulations: full face organic vapor and acid gas
respirator. Full face supplied air
respirator, full face pressure demand self contained breathing apparatus. |
|
PROTECTIVE GLOVES: Any lined non-permeable rubber gloves like
buna or nitrile. |
|
EYE PROTECTION: Wear unvented
goggles during operations in which exposure is likely. Wear full face shield. |
|
OTHER PROTECTIVE CLOTHING OR
EQUIPMENT: Non-permeable clothing to
protect all skin from liquid contact. |
|
RECOMMENDED VENTILATION: Use with appropriate local exhaust
ventilation. Provide appropriate local
exhaust at transfer points. Provide
appropriate local exhaust ventilation on open containers. If exhaust ventilation is not adequate, use
appropriate respiratory protection. |
|
PREVENTION OF ACCIDENTAL
INGESTION: Do not eat or drink or wear
facial cream when using this product.
Do not swallow. |
|
SECTION X - REGULATORY
INFORMATION |
Superfund Amendments and
Reauthorization Act of 1986 (SARA) Title III:
Chemical CAS Number Concentration %
None listed
Federal
EPA: Comprehensive Environmental
Response, Compensation and Liability Act of 1980 (CERCLA) requires notification
of the
Chemical CAS Number Concentration
% Upper Bound
None listed
Hexane 110-54-3 30-40
Dimethoxymethane 109-87-5 10-15
Propane 74-98-6 N/A
Isobutane 75-28-5 N/A
Hexane 110-54-3 30-40
Dimethoxymethane 109-87-5 10-15
Propane 74-98-6 N/A
Isobutane 75-28-5 N/A
NEW
Hexane 110-54-3 30-40
Dimethoxymethane 109-87-5 10-15
Propane 74-98-6 N/A
Isobutane 75-28-5 N/A
Page 3
|
PRODUCT
NAME: |
BELT
GRIP |
|
PRODUCT
CODE: |
50603 |
|
SECTION X - REGULATORY
INFORMATION (continued) |
TOXIC
SUBSTANCES CONTROL ACT (TSCA) STATUS:
Listed
NFPA
RATING AS AN AEROSOL: 3
HMIS: HEALTH 2
REACTIVITY 0 FLAMMABILITY 4
CARCINOGENICITY CHEMICAL IARC NTP OSHA
NOTE:
THE INFORMATION IN
THIS DOCUMENT IS BELIEVED TO BE CORRECT AS OF THE DATE ISSUED. HOWEVER, NO WARRANTY OF MERCHANTABILITY,
FITNESS FOR ANY PARTICULAR PURPOSE, OR ANY OTHER WARRANTY IS EXPRESSED OR TO BE
IMPLIED REGARDING THE ACCURACY OR COMPLETENESS OF THIS INFORMATION OR THE
PRODUCT, THE SAFETY OF THIS PRODUCT, OR THE HAZARDS RELATED TO ITS USE. THIS INFORMATION AND PRODUCT ARE FURNISHED
"AS IS" AND
ON THE CONDITION THAT THE PERSON RECEIVING THEM SHALL MAKE THEIR OWN
DETERMINATION AS TO THE SUITABILITY OF THE PRODUCT FOR THEIR PARTICULAR PURPOSE
AND ON THE CONDITION THEY ASSUME THE RISK OF THEIR USE THEREOF.
Page
4