AIROSOL COMPANY, INC.

MCKAY CHEMICALS             MECHANICS BRAND

11th & Illinois, PO Box 120, Neodesha KS 66757 - Phone 316/325-2666

 

MATERIAL SAFETY DATA SHEET

 

 EMERGENCY INFORMATION

 

MEDICAL:  1-800-633-9576                                                                           TRANSPORTATION:  1-800-535-5053

 

SECTION ONE

 

PRODUCT  NAME:        CHAIN LUBE
PRODUCT  CODE:        50633
ISSUE DATE:                05/17/95 Revised 10/14/99

 

SECTION TWO - HAZARDOUS COMPONENTS

 

                                                            EXPOSURE LIMITS       OSHA         ACGIH                   %          CAS NO

Severely Solvent Refined Heavy Parraffinic Petroluem Oil   5 mg/m3           N/A                   50-55    64741-88-4

Hydrotreated  Bottoms                                                               5 mg/m3           5 mg/m3           20-25    64742-57-0

Severely Solvent Refined Residuum                                             5 mg/m3           5 mg/m3           2-5        64742-01-4

Sulfurized Olefin                                                             5 mg/m3           5 mg/m3           2-5        72162-26-6

Polybutenyl Succinimide/Amide Borate                                        5 mg/m3           5 mg/m3           2-5        84605-20-9

Lube Oil Additive containing Polyisobutylene in Oil                        N/A                   N/A                   1-4        9003-27-4

Solution of Neutral Calcium Dialkene Benzene                              5 mg/m3           N/A                   5          68584-23-6

Sulfonate in Mineral Oil                                                               N/A                   N/A                   <1        64742-55-8

Propane                                                                                    1000ppm           1000ppm           15-25    74-98-6

 

ABBREVIATIONS:  *Stel (ACGIH-TLV)  N/A:  Not Applicable, ND:  Not Determined, NE:  None Established

           

SECTION THREE - PHYSICAL DATA


BOILING POINT:  ND  VAPOR PRESSURE  (mmHg or psig @ 70°F):  75 psig   VAPOR DENSITY (AIR=1)  Heavier than
SPECIFIC GRAVITY (H2O=1):  Less than  SOLUBILITY IN WATER % BY WT. Insoluable   VOC CONTENT % BY WT: 100% EVAPORATION RATE (BUTYL ACETATE=1): Faster Than  APPEARANCE AND ODOR:  Amber, petroleum odor

                                                         

SECTION FOUR - FIRE AND EXPLOSION HAZARD DATA


FLASH POINT:    ND            FLAMMABLE LIMITS:   UEL Not available  LEL  Not available     
EXTINGUISHING MEDIUM:  Dry chemical, foam or carbon dioxide.

 

FIRE AND EXPLOSION HAZARD DATA: 
SPECIAL FIRE FIGHTING PROCEDURES:  Treat as a petroleum fire.  Do not use solid stream of water.


Page 1

PRODUCT  NAME:        CHAIN LUBE
PRODUCT  CODE:        50633

 SECTION FOUR - FIRE AND EXPLOSION HAZARD DATA (continued)

                                                       
UNUSUAL FIRE AND EXPLOSION HAZARDS:  Firefighters should wear SCBA in positive pressure mode with full face shield.  The flammable components are heavier than air and may travel long distances and accumulate in low areas or spread along ground from handling site.  Eliminate all sources of ignition as vapor may ignite.  Carbon oxides may be formed.

SECTION FIVE - REACTIVITY DATA


STABILITY:  This product is stable, avoid open flames and high temperatures (above 120°F) and direct sunlight.

INCOMPATIBILITY:  This product could react vigorously with oxidizing materials.                                                                                                       
HAZARDOUS DECOMPOSITION PRODUCTS:   Carbon dioxide, fumes, smoke, carbon monoxide, sulfur oxide.                         
HAZARDOUS POLYMERIZATION:   Will not occur.                                                

 

SECTION SIX - HEALTH HAZARD DATA

 
EFFECTS OF OVEREXPOSURE:
EYE CONTACT:  This product could cause mild irritation resulting in redness and tearing.
SKIN CONTACT:  Skin irritation could occur if repeated lengthy contact occurs.  Person with existing skin disorders are at times more sensitive to mineral oil; therefore, dermatitis might occur with contact of this product.
SKIN ABSORPTION:  No evidence if skin absorption occurring.

INGESTION:   Considered low order of toxicity.

INHALATION:  Overexposure could cause respiratory tract irritation.  Negligible hazard at ambient (-18 to 38C) or recommended blending temperature.  Avoid breathing vapors or mists.
                                    
EMERGENCY AND FIRST AID PROCEDURES
EYE CONTACT:  Immediately flush eyes with water for at least 15 minutes.  Make sure each eyelid is lifted to allow complete rinsing of solution.  Consult physician promptly.

SKIN CONTACT:  Remove contaminated clothing and completely wash exposed areas with soap and water.  Wash clothing before wearing.
INHALATION:  Remove person to fresh air.  If breathing has stopped, give artificial respiration.  If breathing is difficult, give oxygen.  Call physician immediately if symptoms persist.
INGESTION:  Unlikely, as an aerosol, but if ingested do not induce vomiting. Give 2 full glasses of water.  Keep victim’s head below hips or on their left side with their head down.  Call physician or poison control center immediately.

 

SECTION SEVEN -  ENVIRONMENTAL AND DISPOSAL INFORMATION


ACTION TO TAKE FOR SPILLS/LEAKS:  Eliminate all sources of ignition, ventilate enclosed areas.  Soap up with absorbent.  Place in non-leaking containers for disposal.
WASTE DISPOSAL METHOD:  Dispose of in accordance with local, state, and federal regulations.

 

SECTION EIGHT - HANDLING AND STORAGE PRECAUTIONS

 

Store in tightly sealed containers.  Keep away from heat, sparks and open flame.  Do not get in eyes, on skin or clothing. 

 

Page 2

PRODUCT  NAME:        CHAIN LUBE
PRODUCT  CODE:        50633

SECTION EIGHT - HANDLING AND STORAGE PRECAUTIONS (continued)

 

Do not breathe vapor, mist or gas.  Do not store or transfer to unmarked container.  Do not throw empty containers in

trash compactor.  Do not store in direct sun.  Store containers below 120°F.  Do not throw empty containers into fires.  Read label completely before using.

 

SECTION NINE - SPECIAL PROTECTION INFORMATION


RESPIRATORY PROTECTION (SPECIFY TYPE):   Concentration in air determines protection needed.  Use only NIOSH certified respiratory protection.  Respiratory protection usually not needed unless product is heated or misted.  Half mask air purifier, respirator with dust/mist filter or HEPA filter cartridge is acceptable to 10 times the exposure limit.
VENTILATION:  Local mechanical exhaust ventilation capable of maintaining emissions at the point of use below the PEL/TLV.

PROTECTIVE GLOVES:  Any lined non-permeable rubber gloves.

EYE PROTECTION:  Chemical resistant safety glasses with protective side shields.

OTHER PROTECTIVE EQUIPMENT:  Non-permeable clothing to protect all skin from liquid contact.  Do not eat or drink around this product when using it.  Wash exposed areas with soap and water when finished using.

SECTION TEN  -  REGULATORY INFORMATION


SUPERFUND AMENDMENTS AND REAUTHORIZATION ACT OF 1986 (SARA) TITLE III:
                  CHEMICAL                 CAS NUMBER                CONCENTRATION %
                        None listed       

FEDERAL EPA: Comprehensive Environmental Response, Compensation, and Liability act of 1980 (cercla) requires the notification of the National Response Center of release of quantities of hazardous substances equal to or greater than the reportable quantities (rqs) in 40 CFR 302.4.
                   CHEMICAL            CAS NUMBER                CONCENTRATION % UPPER BOUND   RQs IN #'S

                        None listed       

CALIFORNIA PROPOSITION 65:  None listed

MASSACHUSETTS RIGHT TO KNOW:Yes

                        Propane                        74-98-6                                     5-10
PENNSYLVANIA RIGHT TO KNOW: Yes

                        Propane                        74-98-6                                     5-10

NEW JERSEY RIGHT TO KNOW: Yes

                        Propane                        74-98-6                                     5-10

TOXIC SUBSTANCES CONTROL ACT (TSCA) STATUS: Listed
CALIFORNIA VOC'S: N/A
NFPA RATING AS AN AEROSOL: 3
HMIS:  HEALTH      REACTIVITY      FLAMMABILITY

     
Page 3

PRODUCT  NAME:        CHAIN LUBE
PRODUCT  CODE:        50633

SECTION TEN  -  REGULATORY INFORMATION (continued)

 

CARCINOGENITY          CHEMICAL               IARC              NTP              OSHA
NOT LISTED
CANADIAN WHMIS CLASSIFICATION:

NOTE:  THE INFORMATION IN THIS DOCUMENT IS BELIEVED TO BE CORRECT AS OF THE DATE ISSUED.  HOWEVER, NO WARRANTY OF MERCHANTABILITY, FITNESS FOR ANY PARTICULAR PURPOSE, OR ANY OTHER WARRANTY IS EXPRESSED OR TO BE IMPLIED REGARDING THE ACCURACY OR COMPLETENESS OF THIS INFORMATION OR THE PRODUCT, THE SAFETY OF THIS PRODUCT, OR THE HAZARDS RELATED TO ITS USE.  THIS INFORMATION AND PRODUCT ARE FURNISHED  "AS IS"  AND ON THE CONDITION THAT THE PERSON RECEIVING THEM SHALL MAKE THEIR OWN DETERMINATION AS TO THE SUITABILITY OF THE PRODUCT FOR THEIR PARTICULAR PURPOSE AND ON THE CONDITION THAT THEY ASSUME THE RISK OF THEIR USE THEREOF.


Page 4