AIROSOL COMPANY, INC.
MCKAY CHEMICALS
MECHANICS BRAND
11th &
MATERIAL
SAFETY DATA SHEET
|
PRODUCT NAME: |
MOTOR BLOCK SEALER |
Hmis
Codes: |
H |
F |
R |
P |
|
PRODUCT CODE: |
50911 |
|
|
|
|
|
|
ISSUE DATE |
|
|
2 |
0 |
0 |
0 |
|
SECTION I - MANUFACTURER
IDENTIFICATION |
|
MANUFACTURER’S NAME: |
Airosol Company, Inc. |
|
ADDRESS: |
|
|
EMERGENCY PHONE: |
1-800-535-5053 |
|
INFORMATION PHONE: |
1-800-633-9576 |
|
DATE REVISED: |
|
|
SECTION I I-
HAZARDOUS INGREDIENTS/SARA III INFORMATION |
OCCUPATIONAL
EXPOSURE LIMITS
|
HAZARDOUS COMPONENTS |
CAS NUMBER |
OSHA |
ACGIH |
% |
|
Sodium Tetraborate
Decahydrate |
1303-96-4 |
10
mg/m3 |
5
mg/m3 |
>1 |
|
Hydroxyethyl
Cellulose |
9004-62-0 |
15
mg/m3 |
10
mg/m3 |
>1 |
|
Sodium Acetate |
127-09-3 |
NE |
NE |
>1 |
|
SECTION III- PHYSICAL/CHEMICAL
CHARACTERISTICS |
|
BOILING POINT: |
220°F |
SPECIFIC GRAVITY: |
(H20=1) 1.08 |
|
VAPOR DENSITY: |
1.0 |
EVAPORATION RATE: |
N/A |
|
APPEARANCE AND ODOR: |
Green
particulate, no odor |
SOLUBILITY IN WATER: |
99% |
|
SECTION IV- FIRE AND EXPLOSION
HAZARD DATA |
|
FLASH POINT: |
Nonflammable |
METHOD USED: |
NA |
|
FLAMMABLE LIMITS IN AIR BY VOLUME: |
LOWER: |
NA |
UPPER: |
NA |
|
EXTINGUISHING MEDIA: Apply alcohol-type or all-purpose foam by
manufacturer’s recommended techniques for large type fires. Use CO2 or dry chemical media
for small fires. |
|
SPECIAL FIREFIGHTING PROCEDURES: |
Do not direct a solid stream of water
or foam into burning molten material; this may cause splattering and spread
the fire. Use self-contained breathing
apparatus and protective clothing. |
|
UNUSUAL FIRE AND EXPLOSION
HAZARDS: None. |
|
SECTION V- REACTIVITY DATA |
|
STABILITY: Stable |
|
INCOMPATIBILITY (MATERIALS TO AVOID):
Strong acids |
|
HAZARDOUS DECOMPOSITION OR
BYPRODUCTS: Carbon dioxide and oxide of phosphorous. |
Page
1
|
PRODUCT
NAME: |
MOTOR
BLOCK SEALER |
|
PRODUCT
CODE: |
50911 |
|
SECTION V- REACTIVITY DATA
(continued) |
|
HAZARDOUS POLYMERIZATION: Will not
occur. |
|
SECTION VI- HEALTH HAZARD DATA |
|
INHALATION HEALTH RISKS AND SYMPTOMS
OF EXPOSURE: Will cause irritation of the mucous membranes. |
NATURE
OF HAZARD:
|
SKIN: |
At the present there is no known data
as to the irritation of this product to the skin. |
|
EYES: |
This product could be considered
irritating to the eyes causing redness, tearing and discomfort. |
|
CARCINOGENICITY: |
NTP? |
IARC? |
OSHA REGULATED? |
|
Presently not on any list. |
|
|
|
|
MEDICAL CONDITIONS GENERALLY
AGGRAVATED BY EXPOSURE: NA. |
|
EMERGENCY
AND FIRST AID PROCEDURES: |
|
DIGESTION: If swallowed, INDUCE VOMITING by giving two
glasses of water and placing finger down throat.. |
|
INHALATION: Remove patient to fresh air. Aid in
breathing, if necessary, and get medical attention immediately. |
|
SKIN
AND EYE CONTACT: |
|
EYES:
Immediately flush eyes with large amounts of water for at least 15
minutes. Hold eyelids apart to ensure
complete flushing. Do not attempt to
neutralize with chemical agents. Get
medical help immediately. |
|
SKIN:
Remove contaminated clothing and flush skin with water. Wash with soap and water until material has
been removed. Get medical help immediately. |
|
SECTION VII- PRECAUTIONS FOR
SAFE HANDLING AND USE |
|
STEPS TO BE TAKEN IN CASE LARGE
AMOUNT OF MATERIAL IS RELEASED OR SPILLED:
Use absorbent material to soak up spill, sweep up spill and dispose of
in covered container. Rinse area with
water. |
|
WASTE DISPOSAL METHOD: Dispose of in accordance with federal,
state, and local regulations. |
|
PRECAUTIONS TO BE TAKEN IN HANDLING
AND STORING: Practice good
housekeeping and hygiene. Store in dry
area away from acids. Use with adequate
ventilation. |
|
OTHER PRECAUTIONS: NA. |
|
SECTION VIII- CONTROL MEASURES |
|
RESPIRATORY PROTECTION: NIOSH approved respirator. |
|
VENTILATION: Recommended to maintain dust levels
consistent with generally accepted industrial hygiene and housekeeping
practices. |
|
PROTECTIVE GLOVES: Wear rubber gloves. |
|
EYE PROTECTION: Wear safety goggles. |
|
OTHER PROTECTIVE CLOTHING OR
EQUIPMENT: Long sleeves and long
pants. |
|
WORK/HYGIENIC PRACTICES: |
Page
2
|
PRODUCT
NAME: |
MOTOR
BLOCK SEALER |
|
PRODUCT
CODE: |
50911 |
|
SECTION IX- REGULATORY
INFORMATION |
SUPERFUND AMENDMENTS AND REAUTHORIZATION ACT OF 1986 (SARA)
TITLE III:
CHEMICAL CAS NUMBER CONCENTRATION
%
None
listed
FEDERAL EPA:
Comprehensive Environmental Response, Compensation and Liability Act of
1980 (CERCLA) requires the notification of the
CHEMICAL CAS NUMBER CONCENTRATION
% RQS IN #’s
None
listed
Sodium Tetraborate Decahydrate 1303-96-4
Sodium Tetraborate Decahydrate 1303-96-4
NEW
Sodium Tetraborate Decahydrate 1303-96-4
TOXIC SUBSTANCES CONTROL ACT (TSCA) STATUS: Listed
NFPA RATING AS AN AEROSOL:
NA
|
SECTION X- DISCLAIMER |
NOTE:
THE INFORMATION IN
THIS DOCUMENT IS BELIEVED TO BE CORRECT AS OF THE DATE ISSUED. HOWEVER, NO WARRANTY OF MERCHANTABILITY,
FITNESS FOR ANY PARTICULAR PURPOSE, OR ANY OTHER WARRANTY IS EXPRESSED OR TO BE
IMPLIED REGARDING THE ACCURACY OR COMPLETENESS OF THIS INFORMATION OR THE
PRODUCT, THE SAFETY OF THIS PRODUCT, OR THE HAZARDS RELATED TO ITS USE. THIS INFORMATION AND PRODUCT ARE FURNISHED
"AS IS" AND ON THE CONDITION THAT THE PERSON RECEIVING THEM SHALL
MAKE THEIR OWN DETERMINATION AS TO THE SUITABILITY OF THE PRODUCT FOR THEIR
PARTICULAR PURPOSE AND ON THE CONDITION THEY ASSUME THE RISK OF THEIR USE THEREOF.
Page
3